Suzuki Estilete starter clicks After I stored my Suzuki Estilete in my shed two years ago, I tried to start it again. Motor refuses to rotate. Cannot start with kickstart, seems to be jammed. Cannot start with electric starter, I only hear a click but the motor does not make any revolution. Battery is good condition. Where do I have to look to repair? Thanks in advance.@

Need a faster answer?
Hi, Anonymous before testing any electrical component in the Starting Circuit it is "IMPERATIVE" that you have a fully charged battery of 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage, the battery is faulty and must be replaced. AGM type batteries fall into this scenario more so than lead-acid batteries.
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Check the battery terminals for damage or corrosion check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter.
4. Bank angle sensor needs a reset or is faulty.
5. FOB battery low or dead.
6. Faulty ignition switch.
7. Faulty starter button.
8. Faulty kickstand, clutch, neutral safety switch.
9. Security alarm needs a reset.
10. Starter relay, solenoid, starter motor or circuit wiring faulty.
11. Starter armature or field coils have failed.
12. Main fuse or circuit breaker may be blown or faulty.
13. Faulty ignition relay.
14. The electric starter is working but starter clutch has failed.
15. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
The click no start problem explained
The Ultimate GY6 Starter Ignition Troubleshooting Tutorial
Suzuki UF50 Service Manual
https://www.partsfish.com/page/oem-parts-for-suzuki
http://absolutelyscooterparts.net/pdf/CGEN_dawg_scooter_manual.pdf
Was this answer helpful?
Yes
No
Thank you for your feedback!